Wacker Neuson GPS 5600A Instrukcja Operatora

GeneratorGP 5600AGPS 5600ANon-CARBOPERATOR’S MANUAL0171949en 00206090171949EN

GP/GPS 5600A Safety Information101.3.9 Do not start the engine if fuel has spilled or a fuel odor is present. Movethe generator away from the spill an

GP/GPS 5600A Safety Information111.4 Service SafetyPoorly maintained equipment can become a safety hazard! In orderfor the equipment to operate safel

GP/GPS 5600A Safety Information121.5 Label Locations GND88897

GP/GPS 5600A Safety Information131.6 Safety and Operating LabelsWacker Neuson machines use international pictorial labels whereneeded. These labels ar

GP/GPS 5600A Safety Information14Open the fuel flow valve.Press engine switch to ON position.GPS - Press ignition switch.GP - Pull the rewind starter.

GP/GPS 5600A Safety Information15Only use OUTSIDE and far away from windows, doors, and vents.WARNING! To reduce the risk of electrical shock and arc

GP/GPS 5600A Safety Information16DANGER!No sparks, flames or burning objects near machine.Shut off the engine before refueling.Read the Operator’s Man

GP/GPS 5600A Operation172. Operation2.1 Determining Power RequirementsThis generator is designed to operate single-phase, 60 Hz appliancesrunning at 1

GP/GPS 5600A Operation182.2 InstallationPlace the generator in an area where it will not be exposed to rain,snow, or direct sunlight. Make sure it is

GP/GPS 5600A Operation192.4 Battery Tray Installation (GPS only)2.4.1 Align the holes found in the battery tray (a) to the holes on the framecross-mem

DANGERCARBON MONOXIDEUsing a generator indoors CAN KILL YOU IN MINUTES.Generator exhaust contains carbon

GP/GPS 5600A Operation202.5 Wheel KitThe wheel kit (Part No. 0161308) is a standard item on Item Number0620012, 0620015, 0620043 and 0620046 only. It

GP/GPS 5600A Operation21

GP/GPS 5600A Operation222.6 Generator DeratingAll generators are subject to derating for altitude and temperature.Internal combustion engines, unless

GP/GPS 5600A Operation232.7 Grounding the GeneratorA ground connection (a) is located on the generator frame. For properoperating safety, this ground

GP/GPS 5600A Operation242.9 Use of Extension CordsWhen a long extension cord is used to connect an appliance or tool tothe generator, a voltage loss o

GP/GPS 5600A Operation252.10 Control Panel Ref. Description Ref. Descriptiona Engine Switch g GFCI test buttonb Auto Idle Switch h GFCI reset buttonc

GP/GPS 5600A Operation262.11 Ground Fault Circuit Interrupter (GFCI)The GFCI should be tested for proper operations every time thegenerator is used. N

GP/GPS 5600A Operation272.12 Twist Lock ReceptaclesTwist-lock receptacles (c, j) are used at the 120V Amp and 120/240Voutlets. These receptacles are p

GP/GPS 5600A Operation282.15 Voltage SelectionThe voltage selector switch (e) allows the generator to operate in eithersingle (120V) or dual voltage (

GP/GPS 5600A Operation292.16 Before Starting2.16.1 Read and understand the safety and operating labels and instructionsat the beginning of this manual

wc_tx000240gb.fm 31. ForewordThis manual provides information and procedures to safely operateand maintain this Wacker Neuson model. For your own safe

GP/GPS 5600A Operation302.17 To StartBefore starting, be sure you read and understand all the safety andoperating instructions in this manual.2.17.1 E

GP/GPS 5600A Operation312.18 To Stop2.18.1 Turn off and disconnect all tools and appliances attached to thegenerator.2.18.2 Place the main circuit bre

GP/GPS 5600A Maintenance323. Maintenance3.1 Engine MaintenanceThe chart below lists basic machine and engine maintenance. Refer toyour engine operator

GP/GPS 5600A Maintenance333.3 Engine Oil3.3.1 Drain the oil while the engine is still warm.3.3.2 Remove the oil filler plug (a) and the drain plug (b)

GP/GPS 5600A Maintenance343.4 Servicing Air CleanerService the air cleaner frequently to prevent carburetor malfunction. NOTICE: NEVER run the engine

GP/GPS 5600A Maintenance353.5 Spark PlugClean or replace the spark plug as needed to ensure proper operation.Refer to your engine operator’s manual.

GP/GPS 5600A Maintenance363.6 Cleaning the Sediment Cup3.6.1 Turn the fuel valve off. 3.6.2 Remove the sediment cup (a) and the O-ring (b). 3.6.3 Wash

GP/GPS 5600A Maintenance373.7 Carburetor Adjustment3.7.1 Start the engine and allow it to warm up to operating temperature.3.7.2 Set the pilot screw (

GP/GPS 5600A Maintenance383.9 StorageBefore storing the generator for a long period of time:3.9.1 Close the fuel valve and remove and empty the sedime

GP/GPS 5600A Maintenance393.11 Troubleshooting 3.12 Wire ColorsProblem / Symptom Reason / RemedyIf engine doesn't start, check that:• Engine swit

wc_tx000240gb.fm 4

GP/GPS 5600A Maintenance403.13 Electrical Schematic Ref. Description Ref. DescriptionA Generator D Honda EngineB Control box E Wacker Neuson EngineC

GP/GPS 5600A Maintenance41

GP/GPS 5600A Maintenance423.14 Electrical Schematic (CAN models only) Ref. Description Ref. DescriptionA Generator D Wacker EngineB Control box E

GP/GPS 5600A Maintenance43

GP/GPS 5600A Maintenance443.15 Engine Schematic Ref. Description Ref. DescriptionA Generator E Honda EngineB Control boxC Electric start engines (GPS

GP/GPS 5600A Maintenance45wc_gr004900

GP/GPS 5600A Maintenance46Notes

GP/GPS 5600A Technical Data474. Technical Data4.1 GeneratorItem No. GP 5600A0620382GP 5600A0620381GPS 5600A0620383GeneratorMaximum OutputW5600Continuo

GP/GPS 5600A Technical Data48Item No. GP 5600A CAN0620094GP 5600A CAN0620095GPS 5600A CAN0620096GeneratorMaximum OutputW5600Continuous OutputW5000Type

GP/GPS 5600A Technical Data494.2 EngineEngine Power RatingNet power rating per SAE J1349. Actual power output may vary due toconditions of specific us

GP/GPS 5600A Table of Contents5Foreword 31. Safety Information 71.1 Laws Pertaining to Spark Arresters ...

Wacker Neuson SE · Preußenstraße 41 · D-80809 München · Tel.: +49-(0)89-3 54 02-0 · Fax: +49 - (0)89-3 54 0

Table of Contents GP/GPS 5600Awc_bo0171949en_002TOC.fm 63. Maintenance 323.1 Engine Maintenance ...

GP/GPS 5600A Safety Information71. Safety InformationThis manual contains DANGER, WARNING, CAUTION, NOTICE, andNOTE callouts which must be followed to

GP/GPS 5600A Safety Information81.2 Operating SafetyUsing a generator indoors CAN KILL YOU IN MINUTES. Generatorexhaust contains carbon monoxide. Thi

GP/GPS 5600A Safety Information91.2.8 NEVER allow untrained personnel to operate or service the generator.The generator set should be set up by a cert